Recent Posts

1

Fuel Systems and Drivability / Re: 87 TBI fuel pump insanity

« Last post by Mr Diesel on Today at 10:02:36 AM »

If I am understanding you correctly it sounds like the truck will not run at all off the fuel pump, even when it SOUNDS like the pump is running. But you CAN make it run by pouring fuel down throttle body throat. This tells me your fuel pump is not actually pumping at all, even though you hear what sounds like it running. Based on this, next step is either verify pump can actually pump fuel or just replace it.

2

Engine/Drivetrain / Re: 357 (350 - .40 Over) Build Questions Etc

« Last post by Mike81K10 on April 17, 2024, 10:47:38 PM »

Painted my engine red today. I prefer red to try and match up to my truck.

3

Fuel Systems and Drivability / Re: 87 TBI fuel pump insanity

« Last post by JohnnyPopper on April 17, 2024, 10:03:21 PM »

Dude...there are many peeps here that are over qualified to assist you.

Your challenge is to articulate your points and questions in a form that is easy to understand.

4

Engine/Drivetrain / Re: 357 (350 - .40 Over) Build Questions Etc

« Last post by JohnnyPopper on April 17, 2024, 09:56:57 PM »

Too bad everything is so dirty and needs cleaning! Sheesh!!!

5

Fuel Systems and Drivability / 87 TBI fuel pump insanity

« Last post by Wrought Ire on April 17, 2024, 08:22:00 PM »

Howdy guys, I have the STRANGEST problem going on with my '87 305 tbi not kicking on when I need to start it. Everything on it is fines. It's a pretty clean truck but while I was gone for a couple years in MT it apparently stopped running suddenly. Replaced fuel pump, replaced, fuses, replaced relay, replaced ignition module, replaced lines and hoses. Heres where things get weird.

When I key on theres no fuel pump prime, to start it cranks but again no pump, if I drip gas from a bottle it fires right up and runds until I stop giving it gas. Whe. The truck shuts OFF the fuel pump kicks on like its suppose to to reprise the system. So it works! Better yet when. I connect the test wire from the relay to the battery I csn manually kick on the fuel pump and it sounds lovely! Problem even with the test wire hooked to force the pump to run it won't start, it won't even pump fuel out of the injectors like it's not getting told to do so or something. Idk how these TBI systems work I just know it's an absolute nightmare that doesn't make any sense.

So why would it work every time besides when key on and run, and why when it's forced to run manually would the TBI not inject fuel?

I have NEVER needed to take a vehicle to another mechanic bc i couldnt figure it out and I'm so close to taking a big risk by paying someone else to run around it so annnny help would be greatly appreciated